corvette recall

General Motors Corp. is recalling more than 30,000 Chevrolet Corvettes because of a defect that allows detachable roofs to fly off.

The recall issued this past week affects certain 2005-2006 models with painted roofs. The adhesive between the roof panel and magnesium frame may separate,

[the gill]

how much would that suck to have happen to you :h

the recall or the actual top of the car flying off????? lol.... cuz they both suck... but the 2nd one sucks worse.. lol

[j0n]

old news...tons of roofs have been flying off...check any of the corvette forums

[Joe]

It's not the whole roof, just the top panel :D

http://forums.corvetteforum.com/show....php?t=1369957

Here is the GM bulletin

Subject: Customer Satisfaction - Painted Roof Adhesive Separation #05112A - (02/23/2006)



Models: 2005-2006 CHEVROLET CORVETTE

WITH PAINTED ROOF




--------------------------------------------------------------------------------

STEPS 3 AND 23 IN THE SERVICE PROCEDURE HAVE BEEN REVISED. PLEASE REVIEW THE REVISED PROCEDURE IMMEDIATELY. DISCARD ALL COPIES OF BULLETIN 05112 ISSUED FEBRUARY 2006.


--------------------------------------------------------------------------------

THIS PROGRAM IS IN EFFECT UNTIL MARCH 31, 2007.

Condition
On certain 2005-2006 Chevrolet Corvette vehicles, the painted roof panel may separate from its frame in some areas if it is exposed to stresses along with high temperature and humidity. The occupants of the vehicle may notice one or more of these symptoms: a snapping noise when driving over bumps, wind noise, poor roof panel fit, roof panel movement/bounce when a door or hatch is closed, or a water leak in the headliner.

Correction
Dealers are to apply adhesive foam to ensure proper adhesion, or in a small number of vehicles, replace the roof panel.

Vehicles Involved
Involved are certain 2005-2006 Chevrolet Corvette vehicles with a painted roof, and built within these VIN breakpoints:

Year
Division
Model
From
Through

2005
Chevrolet
Corvette
55100002 thru
55135053

2006
Chevrolet
Corvette
65100001 thru
65100046


Important: Dealers should confirm vehicle eligibility through GMVIS (GM Vehicle Inquiry System) prior to beginning program repairs. [Not all vehicles within the above breakpoints may be involved.]

For US and Canada: For GM dealers, Canadian Saab, and Canadian Saturn retailers with involved vehicles, a Campaign Initiation Detail Report (CIDR) containing the complete vehicle identification number, customer name and address data has been prepared and will be loaded to the GM DealerWorld (US) Recall Information, GMinfoNet (Canada) Recall Reports. For US Saturn retailers only, the involved vehicles are provided in a Facility VIN List file sent to you at your current email address. Dealers/retailers will not have a report available if they have no involved vehicles currently assigned.

For Export: For dealers with involved vehicles, a Campaign Initiation Detail Report containing the complete vehicle identification number, customer name and address data has been prepared, and is being furnished to involved dealers. Dealers will not receive a report with the bulletin if they have no involved vehicles currently assigned.

The Campaign Initiation Detail Report may contain customer names and addresses obtained from Motor Vehicle Registration Records. The use of such motor vehicle registration data for any purpose other than follow-up necessary to complete this program is a violation of law in several states/provinces/countries. Accordingly, you are urged to limit the use of this report to the follow-up necessary to complete this program.

Parts Information
Parts required to complete this program are to be obtained from General Motors Service Parts Operations (GMSPO). Please refer to your "involved vehicles listing" before ordering parts. Normal orders should be placed on a DRO = Daily Replenishment Order. In an emergency situation, parts should be ordered on a CSO = Customer Special Order.

[the gill]

im lookin at the campaign thing on SI, they give you some sort of liquid foam, and a mixing agent the you only have 15 seconds to set everything in place :h

theres a couple other campaigns also,

#05112B Customer Satisfaction - Painted Roof Adhesive Separation - (May 11, 2006)

#06523C Customer Satisfaction - Engine Flywheel/Clutch Interference - (May 2, 2006)

#05086A Product Safety - Power Steering Hose Fracture - (Nov 16, 2005)

[WishIHadACamaro]

typical.